Printed Circuit Board Assembly & PCB Design SMT Electronics Assembly Manufacturing Forum

Printed Circuit Board Assembly & PCB Design Forum

SMT electronics assembly manufacturing forum.


0402 placement skew

#7184

0402 placement skew | 6 July, 2001

Hi guys

I am having problems with skewed placement of 0402 devices I would like to add the board has raised pads and we are placing on glue. We are now printing the glue rather that dispensing with a GL5. have any of you guys had this problem, any info much appreciated

reply »

#7189

0402 placement skew | 6 July, 2001

Oooo, you are waving 0402. Tell us more about your wave and its set-up.

Never seen this [knock on wood]. When is this skewing occurring, after placement or during cure? What�s the distribution? What happens when you slow-down yer placement rate?

reply »

johnw

#7191

0402 placement skew | 7 July, 2001

Dave this seems to be happining at placement altough when u run cal board the palcement is fine could the glue density be causing this

reply »

#7192

0402 placement skew | 7 July, 2001

If your pads are raised as you mentioned, you will reach just the tip of your tiny glue dot, which may not hold the part in place. However, you should be using two glue dots on each side of your 0402 component.

See under adherence force in paste a few days ago.

You should be able to hold the board sideways after placement and the components should stay in place, in particular if you are using a chip shooter for placement.

Stefan

reply »

#7199

0402 placement skew | 9 July, 2001

I sorta believe your Fuji is putting the parts on the spot. My hestitation goes back to a 0402 feeder cal thread that someone-er-other posted last week on SMTnet. Any relation?

Again, we�ve never seen this. Angles to consider are: 1 Placement machine induced torque: Is the P&P head applying twist to the component as either the component enters or during release of the component. The inertia of this torque may remain in the glue for sec and the dissipate by rotating. 2 What is the manufacturer�s intended end use of the glue you are using? => Is the glue intended for printed SMD attach? 3 Are you following all the manufacturer�s glue shelf life recommendations? 4 Are you observing all the manufacturer�s glue working life guidelines?

Finally, what level of skewing are we talking about? What portion of the component termination is off the pad?

reply »

#7217

0402 placement skew | 11 July, 2001

Are you guys providing adequate board support during glue dispense and placement? I've had this same problem with 0603's that I was able to correct with adequate board support. Also, if you're using a Fuji glue machine, what are your temperature settings inside the GL? Make sure they're compatable with the glue manufacturers recommendations. Dispensing glue at too high a temp can effect the glue's green strength. I know a lot of companies that push the temp limit to increase the speed, but they give up placement accuracy and lose in the long run.

reply »

Reflow Oven

SMT spare parts - Qinyi Electronics